AS98BS-N50

AS98BS-N50

AS98BS-N50

主要产品：日本东方马达，韩国DKM减速电机，泰映TROY减速电机，韩国SPG小功率

马达，CPG晟邦减速电机 ...

减速机技术资料：

减速机出厂后，一般规定有200小时左右的磨合期(超过时间必须换油)，这是减速机等机械使用初期的技术特点而规定的。磨合期是保证减速机正常运转，降低故障率，延长其使用寿命的重要环节。桥星减速机公司技术人员给出了以下几个注意事项： 　　(1)、磨合期注意事项 　　1.操作失误多：由于对减速机，如摆线减速机的结构、性能的了解不够(特别是新的操作者)，容易因操作失误引起故障，甚至引起机械事故和安全事故。 　　2.磨损速度快：由于新减速机零部件加工、装配和调试等因素的影响，配合面接触面积较小，而许用的扭距较大。减速机在运行过程中，零件表面的凹凸部分相互嵌合摩擦，磨落下来的金属碎屑，又作为磨料，继续参与摩擦，更加速了零件配合表面的磨损。因此，磨合期内容易造成零部件(特别是配合表面)的磨损，磨损速度过快。这时，如果超负荷运转，则可能导致零部件的损坏，产生早期故障。 　　3.发生松动：新加工装配的零部件，存在着几何形状和配合尺寸的偏差，在使用初期，由于受到冲击、振动等交变负荷，以及受热、变形等因素的影响，加上磨损过快等原因，容易使原来紧固的零部件产生松动。 　　4.润滑不良：由于新装配的零部件的配合间隙较小，并且由于装配等原因，润滑油(脂)不易在摩擦表面形成均匀的油膜，以阻止磨损。从而降低润滑效能，造成机件的早期异常磨损。严重时会造成精密配合的摩擦表面划伤或咬合现象，导致故障的发生。 　　5.发生渗漏现象：由于零件的松动、振动和减速机受热的影响，减速机的密封面以及管接头等处，会出现渗漏现象;部分铸造等缺陷，在装配调试时难以发现，但由于作业过程中的振动、冲击作用，这种缺陷就被暴露出来，表现为漏(渗)油。因此，磨合期偶尔会出现渗漏现象。 　　(2)磨合期注意事项 　　1. 磨合期结束，应对机器进行强制保养，做好检查和调整工作，同时注意油液的更换。 　　2. 在保持减速电机清洁，及时调整、紧固松动的零部件，以防因松动而加剧零部件的磨损或导致零部件丢失。 　　3. 合理选用润滑油，特别是输入功率大于11KW的减速电机须注中负载齿轮油。注意经常检查润滑油、液压油、冷却液、油位和品质，并注意检查整机的密封性。检查中发现油缺少过多，应分析原因。同时，应强化各润滑点的润滑，建议在磨合期内，每周都要对润滑点加注润滑脂(特殊要求除外)。立式带油泵的减速机接电源时注意油泵旋转方向，顺时针旋转为正确。 　　总之，减速机在磨合期内使用保养的要求，可归纳为：加强培训、减轻负荷、注意检查、强化润滑。只要重视并按要求实施对减速机磨合期的保养与维护，就会减少早期故障的发生，延长使用寿命，提高生产效率，使减速机为您带来更多收益。

RELIANCE ELECTRIC 705330-31R USPP 70533031R

Reliance Electric 1326AS-B420G-21, Used, 1326ASB420G21, Fast Shipping

RELIANCE ELECTRIC 6SP401-011CTAN NSFP 6SP401011CTAN

RELIANCE ELECTRIC 804.12.24BYS NSPP 8041224BYS

RELIANCE ELECTRIC 352066-CA NSFP 352066CA

RELIANCE ELECTRIC 804.25.04/CRQ NSPP 8042504CRQ

RELIANCE ELECTRIC 0-51847-1 NSFP 0518471

RELIANCE ELECTRIC 0-51847-4 NSFP 0518474

RELIANCE ELECTRIC 707021-77R NSFP 70702177R

RELIANCE ELECTRIC 0-52850 USPP 052850

RELIANCE ELECTRIC 844933-ST USPP 844933ST

RELIANCE ELECTRIC BRUSHLESS SERVO MOTOR

RELIANCE ELECTRIC 1326AB-B515E-21-L *USED*


1 NEW RELIANCE ELECTRIC 0-51851 PC BOARD L15 

RELIANCE ELECTRIC SERVO MOTOR 1326AS-B330H-21 1326AS B330H 21 1326ASB330H21 

RELIANCE ELECTRIC 0-49011-6A CARDPAK DRIVER MODULE CARD 56026

RELIANCE ELECTRIC 2GU41007 GP2000 7.5HP 460V AC DRIVE ***XLNT***

RELIANCE ELECTRIC 6V41-014TA USPP 6V41014TA

RELIANCE ELECTRIC H-6100-Q-K00AA NSFP H6100QK00AA

**NIB** Reliance Electric PC Board 0-55325-37


RELIANCE ELECTRIC 0-48680-521 NSFP 048680521

Reliance Electric AutoMate 45C1A I/O Rail AutoMax Prog


RELIANCE ELECTRIC 0-56313-1 NSFP 0563131

RELIANCE ELECTRIC 0-52823 NSFP 052823

RELIANCE ELECTRIC 0-52851 NSFP 052851

Reliance Electric 1 HP Motor with Brake 3 PH FREE SHIP

RELIANCE ELECTRIC 78093-2R USPP 780932R

RELIANCE ELECTRIC 0-51818-2 NSPP 0518182

RELIANCE ELECTRIC 0-51839-11 NSPP 05183911

RELIANCE ELECTRIC 5VU41007 USPP 5VU41007

RELIANCE ELECTRIC MAXPAK III 3 HIGH SPEED LINK MODULE 57C424 57C-424 804109-R

RELIANCE ELECTRIC F-4050-Q-H00AA USPP F4050QH00AA

RELIANCE ELECTRIC 0-54339-10 USPP 05433910

RELIANCE ELECTRIC 54339-10 USPP 5433910

RELIANCE ELECTRIC 0-51901-A USPP 051901A

RELIANCE ELECTRIC 1AC2105G USPP 1AC2105G

RELIANCE ELECTRIC 1AC2105U USPP 1AC2105U

RELIANCE ELECTRIC 1AC2103U USPP 1AC2103U

RELIANCE ELECTRIC 69954W **NNB**

RELIANCE ELECTRIC 57C-329C USPP 57C329C

RELIANCE ELECTRIC 57C-409 NSPP 57C409

RELIANCE ELECTRIC 0-57409-F NSPP 057409F

Reliance Electric 57405-E 57405E Analog I/O Drive Module - Refurbished


RELIANCE ELECTRIC 0-49042-1 NSFP 0490421

RELIANCE ELECTRIC 805405000S USPP 805405000S

RELIANCE ELECTRIC 45C-35 USPP 45C35

RELIANCE ELECTRIC 801418-1A USPP 8014181A

RELIANCE ELECTRIC 45C-204-A USPP 45C204A

RELIANCE ELECTRIC 24C201 NSPP 24C201

NEW BALDOR Reliance Electric Duty Master Motor XEX 7.5 HP 3 PHASE 230/460 VOLT
Reliance Electric 0518934 FCCE board, P/N 0-51893-4

RELIANCE ELECTRIC RELAY 3A 300V 64418-1V

RELIANCE ELECTRIC 57C410 ANALOG OUTPUT *NEW*

RELIANCE ELECTRIC BOARD CARD 0-51865-9 51865-9 0518659 NEW IN BOX

Reliance Electric Max Pak V/S. Spindle Drive (4204)

Reliance Electric Max Pak V/S. Spindle Drive (4205)

RELIANCE ELECTRIC DUTY MASTER AC MOTOR 75HP 1785RPM 460V 3PH 365TSC TYPE P 42405

RELIANCE ELECTRIC DCS DISTRIBUTED 803456-21T FIELD POWER SUPPLY 460V 3PH 26390

RELIANCE ELECTRIC 2SR20400 USPP 2SR20400

RELIANCE ELECTRIC 1SU44010 USPP 1SU44010

RELIANCE ELECTRIC 410403-38AW NSPP 41040338AW

RELIANCE ELECTRIC 86466-10S USPP 8646610S

RELIANCE ELECTRIC 0-846747-3R USPP 08467473R

RELIANCE ELECTRIC 78177-2X USPP 781772X

RELIANCE ELECTRIC 811637 USPP 811637

RELIANCE ELECTRIC 14C305 *USED*

RELIANCE ELECTRIC 2MAZ27364 USPP 2MAZ27364

Reliance Electric Hydraulic Pump w/ Motor 1MAF7255

RELIANCE ELECTRIC 0-54394-3 NSFP 0543943

RELIANCE ELECTRIC 0-54394-4 NSFP 0543944

RELIANCE ELECTRIC 78091-2T USPP 780912T

Reliance Electric 0-57411-1A 0574111A Resolver Input Module 1 - Used


RELIANCE ELECTRIC 10P8171B USPP 10P8171B

RELIANCE ELECTRIC 0-49004 CARDPAK D.C AMPLIFIER NIB 


RELIANCE ELECTRIC 64418-1S USPP 644181S

Reliance Electric L0150A 1785 RPM 5 HP 460 Volt RPM AC Motor

Rebuilt Reliance DC Electric Motor 15 Hp 240 V Field/Arm 850/3000 3LA709372T1 SC

NEW Reliance Electric Recitifier Stack 86474-1S #23166

RELIANCE ELECTRIC 18C301 USPP 18C301

RELIANCE ELECTRIC 1SU41010 USPP 1SU41010

RELIANCE ELECTRIC 78091-3T USPP 780913T

RELIANCE ELECTRIC 45C-997 USPP 45C997

RELIANCE ELECTRIC 846747-R NSPP 846747R

RELIANCE ELECTRIC 846747RC NSPP 846747RC

RELIANCE ELECTRIC 0-54339-4 USPP 0543394

RELIANCE ELECTRIC 100859-42R NSPP 10085942R

RELIANCE ELECTRIC 22527-20R NSPP 2252720R

RELIANCE ELECTRIC 22527-20T NSPP 2252720T

RELIANCE ELECTRIC 27106-27X NSPP 2710627X

RELIANCE ELECTRIC 27106-28S NSPP 2710628S

RELIANCE ELECTRIC 2GU41003 USPP 2GU41003

RELIANCE ELECTRIC 0-51850 USPP 051850

Reliance Electric 45C-321/45C321 Power Supply NICE!!!


Reliance Electric 57C-431//57C431/57C431A NICE!!!!


RELIANCE ELECTRIC RT6000256 USPP RT6000256

RELIANCE ELECTRIC 801463-1R USPP 8014631R

RELIANCE ELECTRIC 0-56921-603 USPP 056921603

RELIANCE ELECTRIC 31C301 USPP 31C301

1 NIB RELIANCE ELECTRIC 0-57407-2F 0574072F PRINTED 
CIRCUIT


Reliance Electric AC Motor P44G0607D #37480




RELIANCE ELECTRIC A-C VS DRIVE 1AC2105 USED 1AC2105 

Delco 25hp Electric Motor 1200rpm 32amps 3ph 460v baldor leeson reliance ge 25

RELIANCE 1MAF30764-02-UN 150 HP VERTICAL MOUNT ELECTRIC AC MOTOR ,USED

RELIANCE ELECTRIC 1326AB-B430E-21-L *USED*


1 NIB RELIANCE ELECTRIC PDM-10 PDM10 9101-2161 91012161 SERVO DRIVE 


RELIANCE ELECTRIC PDM-10 9101-2141 POSITION CONTROLLER

1 NIB RELIANCE ELECTRIC 69819-109R 69818109R CARD ASSY


NIB RELIANCE ELECTRIC 801421-3RA 8014213RA POWER SUPPLY


1 NIB RELIANCE ELECTRIC 45C200 I/O PROCESSOR 


RELIANCE ELECTRIC 14C303 FLEXPAK PLUS 20HP *USED*


Reliance Electrical Processor B/M 0-57407-4F Used

RELIANCE ELECTRIC XEX 100 HP 3565 RPM 460V 405TS MOTOR

RELIANCE ELECTRIC 831664 NSPP 831664

RELIANCE ELECTRIC 57C-416S NSFP 57C416S

RELIANCE ELECTRIC 0-52856 NSPP 052856

RELIANCE ELECTRIC 802267-251S NSFP 802267251S

NEW Reliance Electric Communication Module - 57404-M


RELIANCE ELECTRIC 110FN3042 USPP 110FN3042

RELIANCE ELECTRIC 0-57652-A USPP 057652A

RELIANCE ELECTRIC 0-57652 USPP 057652

RELIANCE ELECTRIC 0660-04-076 USPP 066004076

RELIANCE ELECTRIC 61C-542-A USPP 61C542A

RELIANCE ELECTRIC 57C-417 USPP 57C417

RELIANCE ELECTRIC 0-55329-7 USPP 0553297

Reliance Electric 0-51847-1 Voltage Detector Board


Reliance Electric 0-51901-A Printed Circuit Regulator


RELIANCE ELECTRIC 0-52803-2 NSPP 0528032

RELIANCE ELECTRIC 831676 NSPP 831676

RELIANCE ELECTRIC 86466-047R USPP 86466047R

RELIANCE ELECTRIC BATTERY BACKUP 803623-R (B)

RELIANCE ELECTRIC 2GU41005 AC VS DRIVE GP-2000 5 HP 

RELIANCE ELECTRIC 0-56313 NSPP 056313

RELIANCE ELECTRIC 0-57417-B USPP 057417B

RELIANCE ELECTRIC 10H2150 USPP 10H2150

RELIANCE ELECTRIC 801455-4RR NSFP 8014554RR

RELIANCE ELECTRIC 78177-1X NSFP 781771X

Reliance Electric 57413-3F 0- 574133F Memory Module 57C413B - Refurbished


RELIANCE ELECTRIC 801454-R USPP 801454R

RELIANCE ELECTRIC 607980-92C NSFP 60798092C

RELIANCE ELECTRIC 846723T USPP 846723T

RELIANCE ELECTRIC 607980-70B USPP 60798070B

RELIANCE ELECTRIC 45C-17A USPP 45C17A

RELIANCE ELECTRIC 0-56303 USPP 056303

RELIANCE ELECTRIC ELECTRO-CRAFT IQ5000 POSITIONING DRIVE MODULE DM-150 9101-0313

RELIANCE ELECTRIC PMI PROCESSOR 60000-2

RELIANCE ELECTRIC PMI PROCESSOR MODULE CARD PLC 0-60021-4 60021-4 0600214

Reliance Electric Duty Master Motor 25HP

Reliance Electric SP600 7.5HP AC Drive, 6SP401011CTAN

Reliance Electric Motor 40 HP (3) phase / 460 volt / 1775 rpm

50 HP RELIANCE ELECTRIC INVERTER DUTY AC MOTOR w/ PUMP

RELIANCE ELECTRIC RESISTOR KIT 801455-4MRB 14C637 NEW 8014554MRB


Reliance Electric 86466-47S Maxpak Plus Rectifier Stack 460V

Reliance Electric 0-57407-4J Processor Module DCS


RELIANCE ELECTRIC 2-CHANNEL ANALOG INPUT MODULE 57C409

RELIANCE ELECTRIC 69000-3W NEW 460V PRIMARY TRANSFORMER 690003W 


RELIANCE ELECTRIC 0643-04-029 *USED*


RELIANCE ELECTRIC HR2000 / BLA-16-1 BRUSHLESS AC SERVO 


Reliance Electric Electro-Craft Servo-Motor 3200 RPM,24VDC Model#1326AB-B530E-21


RELIANCE ELECTRIC 16 BIT REGISTER OUTPUT MOD 45C-381B

RELIANCE ELECTRIC 0-51865-1 NEW PC BOARD 0518651


Reliance Electric 61C542A Analog Input **FS**


Reliance Electric 20HP 1755RPM 230/460V 3PH Motor 256TC Frame Size

RELIANCE ELECTRIC FCCB BOARD 0-51893-1

RELIANCE ELECTRIC R-NET PROCESSOR 45C202A

Reliance Electric Analog Output Module 45C363


RELIANCE ELECTRIC 0-60023-5 *NEW IN BOX* 


Reliance Electric 0-49029-2 Cardpak Instanteous Electronic Trip 0490292 REM


RELIANCE ELECTRIC CIRCUIT BOARD 803624-15F 091793


Reliance Electric GV3000/SE 7V4160 7.5 HP AC Drive New Surplus in Original Box

RELIANCE ELECTRIC CIRCUIT BOARD CARD 0-57407-2F 57407 2F 574072F NEW

New Reliance Electric 5PY59JY27 Tachometer Generator 2500RPM 100.5VDC


RELIANCE ELECTRIC P25G6903 NSPP P25G6903

RELIANCE ELECTRIC 0-51839 NSPP 051839

RELIANCE ELECTRIC 5V4151 USPP 5V4151

RELIANCE ELECTRIC 0-48680-111 NSPP 048680111

RELIANCE ELECTRIC 0-49001-5 NSFP 0490015

RELIANCE ELECTRIC 0-57401-1 NSPP 0574011

RELIANCE ELECTRIC 0-49026-9 NSPP 0490269

RELIANCE ELECTRIC 0-51862-1 NSFP 0518621

RELIANCE ELECTRIC DDM-005 NSPP DDM005

RELIANCE ELECTRIC 0-57402-D NSFP 057402D

RELIANCE ELECTRIC 57C-402 NSFP 57C402

RELIANCE ELECTRIC 0-54339-11 USPP 05433911

RELIANCE ELECTRIC 54339-11 USPP 5433911

Reliance Electric 0-57407-4 0574074 68000 CPU Module Rev F


Reliance Electric 0-57407-4 0574074 68000 CPU Module REV 4F


Reliance Electric 57406-K 57406K Drive Controller - Refurbished


RELIANCE ELECTRIC 831654 NSPP 831654

RELIANCE ELECTRIC 86471-R NSPP 86471R

RELIANCE ELECTRIC DM-10 USPP DM10

SLS1B19 Federal Pacific Reliance Electric Transformer #10184MO

RELIANCE ELECTRIC 1AC4103U NSFP 1AC4103U

RELIANCE ELECTRIC 11C-428S USPP 11C428S

RELIANCE ELECTRIC IKA859977-XN USPP IKA859977XN

RELIANCE ELECTRIC 2KA867083-RQ USPP 2KA867083RQ

RELIANCE ELECTRIC D4140-002 USPP D4140002

RELIANCE ELECTRIC 846723V USPP 846723V

RELIANCE ELECTRIC 67525-B USPP 67525B

RELIANCE ELECTRIC 0-86466-77S USPP 08646677S

RELIANCE ELECTRIC 0-51668-1 USPP 0516681




Reliance Electric 45C-400A/45C400A/45C400/45C-400


Reliance Electric 0-51381-13/05138113 Controller Card


RELIANCE ELECTRIC 60000-3 USPP 600003

RELIANCE ELECTRIC 0-51445-A NSPP 051445A

RELIANCE ELECTRIC 0-54392-2 NSFP 0543922

Reliance Electric 803456-21T 80345621T Field Supply DCS Power Module - Used


M3452H9C00, Reliance Electric Power Supply 460AC 640DC

RELIANCE ELECTRIC 0-49017-16A USPP 04901716A

Reliance Electric Company 0-51865-1 Board - Used


RELIANCE ELECTRIC 2GU41002 NSPP 2GU41002

RELIANCE ELECTRIC 419021-1C NSFP 4190211C

RELIANCE ELECTRIC 86475-10R NSFP 8647510R

RELIANCE ELECTRIC PSBD-5 SD-68236 POWER SUPPLY TESTED! QUANTITY!!

RELIANCE ELECTRIC 29501-1XE NSPP 295011XE

RELIANCE ELECTRIC 38C80 USPP 38C80

RELIANCE ELECTRIC 57412-E USPP 57412E

RELIANCE ELECTRIC 0-54381 NSFP 054381

RELIANCE ELECTRIC 109050-17S NSFP 10905017S

RELIANCE ELECTRIC 5PY59JY27 USPP 5PY59JY27

RELIANCE ELECTRIC SERVO MOTOR S-3007-N-H00AA

RELIANCE ELECTRIC 846747-R USPP 846747R

RELIANCE ELECTRIC 796896-R USPP 796896R

RELIANCE ELECTRIC 27106-27R USPP 2710627R

RELIANCE ELECTRIC 27106-27S USPP 2710627S

RELIANCE ELECTRIC 27106-28V USPP 2710628V

RELIANCE ELECTRIC 27106-28Y USPP 2710628Y

1 NIB RELIANCE ELECTRIC 57C410 ANALOG OUTPUT 4 CHANNEL 


BALDOR RELIANCE CTM2332T 10HP 3 PHASE ELECTRIC MOTOR 

Reeves Reliance 10HP R373890-001 Variable Speed Drive Electric

Reliance Electric VS Drive GP2000 2GU41015 Type 1 Enclosure 15 HP 3ph W/HMCP 100

Enlarge
SERVO MOTOR RELIANCE ELECTRIC MODEL F-4065-S-00AX

RELIANCE ELECTRIC FLEXPACK PLUS 14C103

RELIANCE ELECTRIC FLEXPACK PLUS 14C103

RELIANCE ELECTRIC 2DF4285 USPP 2DF4285