DG130R-ARMAD-1

主要产品：日本东方马达，韩国DKM减速电机，泰映TROY减速电机，韩国SPG小功率

马达，CPG晟邦减速电机 ...

销售热线: 180-6090-9625/0592-6013512

联系人：兰工

      QQ: 869740621

减速机技术资料：

在选择减速机的型号时应注意的几个事项：尽量选用接近理想减速比：减速比=伺服马达转速/减速机出力轴转速扭力计算：对减速机的寿命而言，扭力计算非常重要，并且要注意加速度的最大转矩值（TP），是否超过减速机之最大负载扭力。
适用功率通常为市面上的伺服机种的适用功率，减速机的适用性很高，工作系数都能维持在1.2以上，但在选用上也可以以自己的需要来决定，要点有二：A.选用伺服电机的出力轴径不能大于表格上最大使用轴径；B.若经扭力计算工作，转速可以满足平常运转，但在伺服全额输出时，有不足现象时，我们可以在电机侧之驱动器，做限流控制，或在机械轴上做扭力保护，这是很必要的。
通用减速机的选型包括提出原始条件、选择类型、确定规格等步骤。
相比之下，类型选择比较简单，而准确提供减速器的工况条件，掌握减速器的设计、制造和使用特点是通用减速器正确合理选择规格的关键。
规格选择要满足强度、热平衡、轴伸部位承受径向载荷等条件。
1.按机械功率或转矩选择规格（强度校核）通用减速器和专用减速器设计选型方法的最大不同在于，前者适用于各个行业，但减速只能按一种特定的工况条件设计，故选用时用户需根据各自的要求考虑不同的修正系数，工厂应该按实际选用的电动机功率（不是减速器的额定功率）打铭牌；后者按用户的专用条件设计，该考虑的系数，设计时一般已作考虑，选用时只要满足使用功率小于等于减速器的额定功率即可，方法相对简单。
通用减速器的额定功率一般是按使用（工况）系数KA=1（电动机或汽轮机为原动机，工作机载荷平稳，每天工作3~10h，每小时启动次数≤5次，允许启动转矩为工作转矩的2倍），接触强度安全系数SH≈1、单对齿轮的失效概率≈1%，等条件计算确定的。
所选减速器的额定功率应满足：PC=P2KAKSKR≤PN式中PC———计算功率（KW）；PN———减速器的额定功率（ KW）；P2———工作机功率（KW）；KA———使用系数，考虑使用工况的影响；KS———启动系数，考虑启动次数的影响；KR———可靠度系数，考虑不同可靠度要求。
目前世界各国所用的使用系数基本相同。虽然许多样本上没有反映出KS\ KR两个系数，但由于知己（对自身的工况要求清楚）、知彼（对减速器的性能特点清楚），国外选型时一般均留有较大的富裕量，相当于已考虑了KR\ KS的影响。
由于使用场合不同、重要程度不同、损坏后对人身安全及生产造成的损失大小不同、维修难易不同，因而对减速器的可靠度的要求也不相同。系数KR就是实际需要的可靠度对原设计的可靠度进行修正。它符合ISO6336、GB3480和AGMA2001—B88（美国齿轮制造者协会标准）对齿轮强度计算方法的规定。目前，国内一些用户对减速器的可靠度尚提不出具体量的要求，可按一般专用减速器的设计规定（SH≥1.25，失效概率≤1/1000），较重要场合取KR=1.25=1.56左右。
2、热平衡校核通用减速器的许用热功率值是在特定工况条件下（一般环境温度20℃，每小时100%，连续运转、功率利用率100%），按润滑油允许的最高平衡温度（一般为85℃）确定的。条件不同时按相应系数（有时综合成一个系数）进行修正。
所选减速器应满足：PCt=P2KTKWKP≤Pt式中 PCt———计算热功率（KW）；母线加工机KT———环境温度系数；KW———运转周期系数；KP———功率利用率系数；Pt———减速器许用热功率（KW）。
3.校核轴伸部位承受的径向载荷通用减速器常常须对输入轴、输出轴轴伸中间部位允许承受的最大径向载荷给予限制，应予校核，超过时应向制造厂提出加粗轴径和加大轴承等要求。

OMRON # 3G2A6-OC222 PROG.CONTROLLER NEW IN BOX

OMRON Z4LB -CV2 PARALLEL BEAM SENSOR

Siemens 6ES5430-4VA13 Digital Input Module

OMRON C28K-CDR-D1020C *NEW OUT OF A BOX*


OMRON CS1W-MCH71 MOTION CONTROL UNIT CS1WMCH71, MCH71


OMRON P5+ SERIES AC DRIVE

OMRON OUTPUT UNIT 3G5A2-OC221 B500-OC221 

Magnetek GPD 315 MVA025 / Omron IDM 3G3MV 7.5 HP, 230V


OMRON PJLH-55 LJLH55 Video Memory x3

OMRON V530-R160/F150-KP

OMRON # 3G2A6-OD412 PROG.CONTROLLER NEW IN BOX 

OFFER & WIN- OMRON CS1W-IC102 I/O CONTROL UNIT

ZFV-SH50 Omron New In Box Vision Sensor ZFVSH50


Omron R88DUA20V AC Servo Drive with cables

(AB01) AC SERVO DRIVER OMRON R88D-HS04 WORKING

C200H-RT201 Omron PLC New In Box Remote I/O Rack Interface C200HRT201

C200H-RT201 Omron PLC New In Box Remote I/O Rack Interface C200HRT201


OMRON C500-GPC03 GRAPHIC PROGRAMMING CONSOLE 

OMRON IDM P5+ INVERTER WITH VT5 CONTROLLER

(AJ01) CJ1G-CPU45H OMRON SYSMAC NEW

C200H-DA003 Omron PLC New In Box Analog Out C200HDA003


HPLC ALLIANCE ANALYTICAL AIR/LIQUID LAB MANIFOLD OMRON H3CA

CS1G-CPU44H Omron PLC New In Box CPU CS1GCPU44H


Matching Rack Cabinets w/Omron Sysmac C200HGCPU63 PLC System

Omron C200H Program Control Enclosure Complete Set-Up 

Nice Omron AC Servo Drive Driver R88D-HT04 200/220VAC 65VA 


C60K-CDS1-A New In Box Omron PLC CPU C60KCDS1A


C60K-CDT1-D New In Box Omron PLC CPU C60KCDT1D


(AB01) DRIVER-AC SERVO OMRON R88D-HS04 WORKING

(AB01) I/O UNIT OMRON FN515-MX212 WORKING

Omron Compplete PLC Sysmac C200H CPU C200H-CPU21-E


(AB01) DATA CONVERTER OMRON C500-AD101 D/A UNIT WORKING

(AB01) OMRON SYSMAC CQM1 PROGRAMMERBLE CONTROLLER PA203 CPU21 ID212 OD212 WORKIN

(AB01) POWER SUPPLY OMRON R88S-H205G WORKING

New Omron Power Supply, C500-PS213-E


Omron R88D-WT08H Servo Drive 200V 600-750W ! WOW !

C500-CP131 Omron PLC CAM Positioner Module C500CP131


CQM1-CPU44-E Omron PLC New In Box CPU CQM1CPU44E


OMRON C500-NC111-EV1 SERVO MODULE SINGLE AXIS STEPPER

(AA01) OMRON R88D-HT04 AC SERVO DRIVER WORKING

Omron E6F-AG5CC Rotary Encoder for H8PR-32 H8PR-16 H8PS-8PF Cam Positioners NEW

OMRON AC Vector Drive Model CIMR-G5U420P2 Pec#42P21F G5+ Series

(AJ01) OMRON PLC SYSMAC CJ1W-PA202 CJ1M-CPU13 NC113 X 2EA ID261 X 2EA TERMINAL

Omron Capacitive Proximity Switch E2K-C25ME2 Lot of 14 Brand New

OMRON CV500-RM211 REMOTE I/O UNIT GOOD TAKEOUT

OMRON V680-CA5D02 RFID SYSTEM ID CONTROLLER 24VDC NEW

OMRON CV500-SLK21 SYSMAC LINK UNIT For PLC REFURBISHED

OMRON CJ1W-V600C12 USPP CJ1WV600C12

OMRON F210-C10 & F160-KP without Camera&Monitor ,Vision Controller sn:22405

Omron Interactive Display NT631C-ST141-EV1 

OMRON C200PC-ISA12-1 C200PC C200PC-CN221 Cable

Omron CJ1G-CPU44H CJ1GCPU44H NIB Free Ship

OMRON C200H-NC211/C200HNC211 Dual Axis Motion Module New!! OFFERS ACCEPTED!!


OMRON NT620S-ST211B HMI Touch Panel

Omron R88D-UA20HA AC Servo Driver NIB Free Ship 

OMRON CPU Unit C200HX-CPU64-E New in Old Box Free Ship

OMRON CPU Unit C200HE-CPU33-E New in Box Free Ship

Omron NT600S-ST121B-V1 Diplay Panel Free Ship

Omron AC Servo Motor R88M-U1K030H-BS1 Free Ship

Omron IG000 3G8B3-IG000

OMRON C200PC-ISA13 C200PC with C200PC-CN221 Cable

Omron NT31C-ST142B-EV2 interactive display

Omron CJ1W-NC433 Free Ship

OMRON C250HL-CPU01-MK CPU UNIT/PLC ***XLNT***

Omron C200HX-CPU85-ZE C200HW-CLK21 C200H-CT021 PLC

Omron NT600S-ST121B-V3 Interactive Display Free Ship



OMRON HMI NT631C-ST151B-EV1 Touchscreen Free Ship

Omron NT631C-ST141-EV2 Free Ship

OMRON V530-LGCRXXX CORE 2D IMAGER HEAD NEW HARD TO FIND

OMRON NT620S-ST141 Free Ship

OMRON V680-CA5D01 V680CA5D01 ID CONT NEW

NEW KAWASAKI 9EH005282 ROBOT PC BOARD 10999EH02 OMRON XC2A 6412 8900 9EH-32 S4


Omron Interactive Display NTH25-ST121B Free Ship

OMRON ZX2-LD50L Free Ship

Omron NT631C-ST151-E Interactive Display Touchscreen 

Omron CQM1-CPU43-V1 CQM1CPU43V1 CPU Controller

Omron E5ZE-8AQH04PB E5ZE8AQH04PB Temperature Controller 24VDC

OMRON Servo Motor R88M-W1K530H-BS2 Free Ship

OMRON C40H-C5DR-DE-V1 NSFP C40HC5DRDEV1

KEYENCE VISION CAMERA / CV-130 / CV-C11/ LED Light /Monitor /Remote Control

OMRON C200H-MAD01 ANALOG 2 IN/2 OUTPUTS

24032 NEW Omron 3F88L-132 Cam Positioner 100-240VAC 50/


LDQ-100A OMRON LED LIGHT *NEW*


Omron 3G2A5-OC221


Omron CV500-SLK11


Omron 3G2A5-OD213


Omron CVM1-BC053


Omron 3G2A9-BAT05


Omron 3G2C2-SI021


Omron E3N2-D2Y4B-US


Omron 3G2C5-BC001


Omron xy2z-100j-a1


Omron 3G2C5-DPL01-E


Omron 3G3MV-A2001


Omron c200h-bc000-v1


Omron C500-ID219


Omron C200H-BC101-V2


Omron 3G207-IP002


Omron E2CJ-R2-F


Omron 3G2A3-OD411


Omron C200HG-CPU43


Omron C200H-OD218


Omron 3G2A5-ID213


Omron CS1WBC102


Omron CV500-BC101


Omron 3G2A5-ID219


Omron 3G2A6-PRO15E


Omron CV500-II101


Omron 3G2A5-OA222


OMRON V530-H301 2D WAND V530H301 "NIB"


OMRON V530-R150E-3 "NIB" V530R150E3 CODE READER


Omron NSH5-SQR00B-V2 Handheld Interactive Display NEW E17

Omron NS5-MQ00B-V2 Interactive Display Touchscreen NEW A7

Omron,Minisafe,STI, MSF4800S-20-0600-10X-10R 


OMRON F3SN-A0607P25-D Sensors *NIB* International Shipping Available 


OMRON C500-NC103 NSPP C500NC103



OMRON V600-CA1A-N NSFP V600CA1AN

Omron STI MS430BB-2 MiniSafe Safety Light Curtain
MS4300B-2 Series Transmitter and Receiver MiniSafe-B

OMRON C200HW-SLK13 USPP C200HWSLK13

BRAND NEW OMRON PC CIRCUIT BOARD MODEL ORN-DSP-A2/2

Omron NT631C-ST141B-E Display Panel Free Ship

Omron NT631C-ST141B-V2 Display Panel Free Ship

OMRON CV500-MC421/CV500MC421 Servo Controller


Omron NT600G-DT212 NT600M-RT121 Free Ship

C200H-NC211 Omron PLC New In Box 2-Axis C200HNC211


V530-H301 Omron New In Box 2D Code Reader V530H301


OMRON SGMAH-08AAA61D-OY NSFP SGMAH08AAA61DOY

OMRON # C200H-TC003 CONVERTER MODULE, NIB

OMRON V600-CA1A-V2 NSPP V600CA1AV2

Omron C500-OD415CN, Used, C500OD415CN, Fast Shipping

Omron CJ1W-ETN21, Used, CJ1WETN21, Fast Shipping

OMRON C200HX-CPU44 USPP C200HXCPU44

Omron C200H-ASC11 C200HASC11 ASCII Unit

Omron PLC CS1G CPU44-V1 , CLK21 , DRM21 , ETN11 (E)

OMRON V620-CA1A USPP V620CA1A

OMRON CV500-BI111 NSPP CV500BI111

Omron NT31C-ST143B-EV3 NT31CST143BEV3 New in Box Free Ship

New OMRON touch screen NT31C-ST143B-EV3

OMRON C60K-CAR-A USPP C60KCARA

OMRON E4P-ALS400M1 NSFP E4PALS400M1

OMRON C40H-C6DR-DE NSFP C40HC6DRDE

Omron 3G3XV-A2004


Qty 6. Keyence LX2-V10W Digital Display Amps, Custom Setup, w/ 2 Omron Relays 

1 new OMRON - C200H-NC211 - 2-AXIS STEPPER CONTROL-new

OMRON C200HW-NC113 NSFP C200HWNC113

OMRON C500-DA004 USPP C500DA004

OMRON C1000H-CPU01-EV1 USPP C1000HCPU01EV1

OMRON C1000H-CPU01-V1 USPP C1000HCPU01V1

OMRON C1000H-CPU01-E USPP C1000HCPU01E

OMRON C200HS-CPU01 USPP C200HSCPU01

Omron R7D-AP08H R7DAP08H Servo Drive

C200HGCPU63E NEW OMRON C200HG CPU63 E FREE SHIPPING


Omron C200HW-COM03-V1 C200HWCOM03V1

Omron NT631C-ST151B-EV1 Interactive Display HMI 

OMRON C500-CT021 NSFP C500CT021

OMRON F10-S30R NSFP F10S30R

OMRON C200HG-CPU43-E

OMRON E3MC-MX11 USPP E3MCMX11

New Omron PLC CJ1M-CPU11-ETN

OMRON R88D-UP03H-AAC200V-50W USPP R88DUP03HAAC200V

OMRON H8PB-Y-30 USPP H8PBY30

OMRON H8PB-Y USPP H8PBY

OMRON NT20S-ST121B-EV3 USPP NT20SST121BEV3

OMRON R88D-UA03HA NSFP R88DUA03HA

OMRON E3MC-X11 USPP E3MCX11

OMRON F3W-A162-D USPP F3WA162D